So you grew up on Hamburger Helper, but now you’re an adult and have a more ✨refined✨ palate (read: sarcasm). Well, this One Pot Chili Mac recipe is your grown-up “I actually know how to cook now” substitute! And don’t worry, it’s almost just as easy as the boxed mix. Promise. It’s rich, hearty, cheesy, beefy comfort food pasta all cooked in one easy-to-clean pot. WIN!
All recipes are rigorously tested in our Nashville Test Kitchen to ensure they are easy, affordable, and delicious.
What Is Chili Mac?
Chili Mac is simply macaroni noodles drenched in a rich tomato-based meat sauce, seasoned with chili spices, and with plenty of creamy cheddar cheese melted in. Some recipes also include beans, but I’m going for more of a Hamburger Helper dupe with mine, so I went sans beans. And you might be thinking, “I call that Goulash in my house.” While Chili Mac is similar to American Goulash in that they both contain macaroni noodles and a tomato-based meat sauce, they differ in their seasonings and flavor profiles.
Ingredients for Chili Mac
Here’s what you’ll need to make your own homemade chili mac:
- Onion and Garlic: The delicious meat sauce starts with onions and garlic sautéed in olive oil to give the beef plenty of flavor.
- Ground Beef: Ground beef makes this dish super hearty and delicious, while still being quick and easy to make. Opt for 85 or 90% lean ground beef to avoid having to drain the fat from the pan.
- Flour: A little flour cooked into the sauce helps thicken it up into a delicious gravy-like consistency.
- Spices: A mix of spices are added to the sauce for maximum flavor, including chili powder, smoked paprika, garlic powder, and oregano.
- Tomato Sauce: Tomato sauce gives the sauce a tangy tomato flavor and adds to the chili flavor profile.
- Beef Broth: Beef broth adds tons of flavor to this dish and enough salt to keep everything properly seasoned. If using a low-sodium broth, you may need to add a little salt at the end to taste to really help the flavors pop. We used Better Than Bouillon to make our beef broth for maximum flavor.
- Macaroni: Macaroni noodles are an inexpensive and filling ingredient that helps stretch the cost of the beef and keep the entire recipe budget-friendly.
- Cheddar Cheese: Cheddar cheese is stirred into the sauce and added on top of the noodles for extra cheesy flavor!
What Else Can I Add?
If you want to take your chili mac to the next level, try adding one or more of these ingredients:
- Drained kidney or black beans
- Frozen corn kernels
- Sliced green onions
- Pickled jalapeños
- Diced tomatoes (or tomatoes with green chiles)
- Chipotle chile powder
What to Serve with Chili Mac
Chili mac is a true meal in a bowl, but if you want to serve something on the side I’d go for something fresh and light like Cowboy Caviar, Sweet Corn Salsa, or even Cumin Lime Coleslaw.
Storing and Reheating Leftovers
As with any pasta dish, the macaroni will continue to get softer as it absorbs moisture from the sauce, so if softer pasta is not tolerable to you, you may not enjoy the leftovers. That being said, I will gobble up these leftovers without a second thought and love making this Chili Mac for meal prep and even to stock my freezer. I simply refrigerate single-serving portions for up to five days or freeze for up to three months. Let frozen portions thaw in the refrigerator overnight, then reheat using the microwave.
One Pot Chili Mac
Servings 6 (1 cup each)Ingredients
- 1 yellow onion ($0.32)
- 2 cloves garlic ($0.16)
- 1 Tbsp olive oil ($0.16)
- 1 lb. ground beef ($5.99)
- 2 Tbsp all-purpose flour ($0.03)
- 1 Tbsp chili powder ($0.30)
- 1/2 tsp smoked paprika ($0.05)
- 1/2 tsp garlic powder ($0.05)
- 1/2 tsp dried oregano ($0.05)
- 8 oz. tomato sauce ($0.69)
- 3 cups beef broth ($0.32)
- 1/2 lb. uncooked macaroni (about 2 cups) ($0.50)
- 1 cup shredded cheddar ($1.17)
Instructions
- Dice the yellow onion and mince the garlic. Add the onion and garlic to a large deep skillet or Dutch oven with the olive oil and sauté over medium heat until the onions are soft and translucent (about 5 minutes).
- Add the ground beef to the skillet and continue to stir and cook until the beef is cooked through. If using a higher fat content ground beef, you may want to drain off the excess fat at this point.
- Add the flour, chili powder, smoked paprika, garlic powder, and oregano to the skillet with the beef and onions. Continue to cook and stir for about two minutes, allowing the flour and spices to coat the bottom of the skillet, but not burn.
- Add the tomato sauce and beef broth to the skillet and stir well to combine, making sure to scrape and dissolve any browned bits off the bottom of the skillet.
- Add the uncooked macaroni and stir to combine. Place a lid on the skillet and turn the heat up to medium-high. Allow the broth to come up to a full boil. Once boiling, give the pasta a quick stir to loosen any that is stuck to the bottom, turn the heat down to medium-low, and place the lid back on top.
- Allow the macaroni to simmer, stirring every few minutes and always replacing the lid, until the macaroni is tender and the broth has reduced to a rich red gravy (about 10 minutes).
- Stir half of the shredded cheese into the sauce until melted, and sprinkle the remainder on top. Place a lid on the pot, turn the heat off, and allow the residual heat to melt the cheese on top. Serve hot and enjoy!
See how we calculate recipe costs here.
Equipment
- Deep Stainless Steel Skillet
Nutrition
Have you tried this recipe?Mention @budgetbytes or tag #budgetbytes on Instagram!
How to Make Chili Mac – Step by Step Photos
Dice one yellow onion and mince two cloves of garlic. Add the onion and garlic to a large deep skillet or Dutch oven with 1 tablespoon of olive oil and sauté over medium heat until the onions are soft and translucent (about 5 minutes).
Add one pound of ground beef to the skillet and continue to stir and cook until the beef is fully browned. If you’re using a higher fat content beef, drain the excess fat out of the pan. Next, add 2 tablespoons of flour, 1 tablespoon of chili powder, ½ teaspoon of smoked paprika, ½ teaspoon of garlic powder, and ½ teaspoon of dried oregano.
Continue to stir and cook the flour and spices into the beef for about two minutes, allowing it to coat the bottom of the skillet, but not burn.
Add one 8oz. can of tomato sauce and three cups of beef broth to the skillet. Stir well until everything is evenly combined, making sure to scrape and dissolve all of the browned bits off the bottom of the skillet.
Add ½ pound (about 2 cups) of uncooked macaroni to the skillet and stir to combine. Place a lid on the skillet, turn the heat up to medium-high, and allow the broth to come up to a boil. Once boiling, give everything a quick stir to loosen any macaroni from the bottom of the skillet, turn the heat down to medium-low, and place the lid back on top.
Let the macaroni simmer in the broth, stirring every few minutes or so and always placing the lid back on top, until the macaroni is tender and the broth has reduced to a saucy red gravy (about 10 minutes).
Add ½ cup of shredded cheddar cheese to the chili mac and stir it into the sauce until melted.
Sprinkle the remaining ½ cup of shredded cheese on top. Place a lid on the skillet and turn the heat off. Let the residual heat melt the cheese, then serve. You can garnish with chopped cilantro or sliced green onions, if desired.
So cheesy, beefy, and delicious!!
This is a great recipe! I made it when I couldn’t get to the store, so I had to improvise and use what I had on hand. I made my own tomato sauce by blending tomato paste and diced tomatoes (both with basil, oregano, and garlic.) I only had whole wheat elbow macaroni, so I needed to increase the simmer time to about 15 minutes. I used reduced fat Mexican cheese, also. It all turned out beautifully! Beef Better Than Bouillon added an extra depth to the gravy. Next time I am going to add a little white pepper for some subtle heat.
SO GOOD. I added sour cream and it’s phenomenal. Super easy, and ingredients are usually always on hand. Thanks for this recipe :)
I have made this recipe 3 times now. The first time as directed, the other times I’ve added 2 bell peppers and some cinnamon. It is absolutely delicious! Would highly recommend this to anyone looking for some yummy comfort food, or someone looking for a really easy fast 1 pot meal. Definitely a 5 star!
I make this all the time, doubled for because I have three active teens. I use cornstarch instead of flour to make the gravy extra silky.
Yum! I really enjoyed this. It was easy and flavorful. I used impossible beef and added salt and pepper. I don’t know if my broth was reduced salt but it definitely needed some added. I topped it with sour cream because I’m about that sour cream life.
Great recipe, thank you for sharing! I ended up making a double batch of this for a work potluck, and added a few cans of beans since it seemed a little on the thin side. Also, had to add more chili powder because it tasted a bit bland (but that’s all personal preference). Thanks again!
I always try to make recipes so that we can have leftovers for another night. This was pretty good on the first night but the very next night that we ate it it was very dry. Any recommendations? I saw something in the comments about how the old recipe used 1 extra cup of broth, should I try that?
You could definitely try adding that extra cup of broth if you’re planning on keeping leftovers! You could also just add a splash when you’re reheating as well.
I cut the recipe in half because we are a family of 3. I ended up adding a little extra broth because the pasta needed it to cook.
The end result was a little on the bland side but chopped parsley and some green onion helped a lot. Next time I’d use tomato paste for more flavor and a little extra chili powder.
Lol, also, it beats me why I didn’t realize this is a recipe for hamburger helper.
Awesome recipe! I had to make minor modifications based on what I had, subbing tomato paste for tomato sauce and chicken broth for beef broth and it still came out delicious. Added in some black beans as suggested plus topped with avocado slices.
3 cups of beef broth made this recipe too salty. Otherwise it tasted good.
I like to do something halfway between this and the vegetarian chili mac – half meat/ half beans plus tomatoes and whatever veggies are on hand. Always comes out great!
My husband and I grew up on hamburger helper too. I still eat it from time to time but my husband doesn’t care for it. I love recipes like this that recreate it but it tastes homemade and fresh AND my husband will tolerate it!! My kiddos gobbled it up as well. Thanks!!
I made this according to the recipe, with the one exception of adding a little American cheese with the cheddar, and it was nice. It was wetter than similar dishes I’ve made, but it was saucy, not brothy. Very pleasant. Next time I’ll personalize it a bit with green bell and cumin, and maybe some other things, but this is a great recipe.
Followed recipe as is and added corn, kidney beans, and a teensy bit of Dijon (no idea why I felt the need but so glad I added it!) and this is soo delicious. Not brothy at all like other comments indicated, those reviews confused me lol. I’ve been using this website since January and every single recipe has been a hit. I’m so happy I found this website 😊
This contributor has become a favorite of mine. Her recipes are always healthy and delicious and this one is no exception! My kids ate it all up and that’s a win in this house!!